2016 Chevrolet Malibu
Counts come from unverified consumer complaints filed with NHTSA and cannot be compared between models — how to read them.
Common problems reported on the 2016 Chevrolet Malibu
| Component group | Complaints | Share |
|---|---|---|
| Engine | 274 | 35.4% |
| Electrical System | 197 | 25.5% |
| Power Train | 158 | 20.4% |
| Unknown or Other | 158 | 20.4% |
| Vehicle Speed Control | 144 | 18.6% |
| Service Brakes | 92 | 11.9% |
| Electronic Stability Control (ESC) | 75 | 9.7% |
| Fuel/Propulsion System | 43 | 5.6% |
| Steering | 39 | 5.0% |
| Structure | 37 | 4.8% |
| Exterior Lighting | 18 | 2.3% |
| Suspension | 18 | 2.3% |
773 complaints filed between October 14, 2015 and December 8, 2024.
At what mileage the Chevrolet Malibu failed
| Component group | Median | Reports |
|---|---|---|
| Engine | 51,000 | 168 |
| Electrical System | 48,650 | 132 |
| Power Train | 40,750 | 104 |
| Vehicle Speed Control | 60,000 | 97 |
| Service Brakes | 57,000 | 63 |
| Electronic Stability Control (ESC) | 55,000 | 62 |
| Fuel/Propulsion System | 54,821 | 28 |
| Steering | 49,000 | 28 |
| Structure | 39,500 | 24 |
| Exterior Lighting | 41,500 | 12 |
Across all components, half the reported failures happened before 50,000 miles, with the middle half falling between 30,000 and 70,600. Based on the 514 complaints (66%) that record a mileage.
A low figure does not mean the car stops working at that mileage. It means the reported failures clustered early, which most often points to a fault built into a production batch — usually the kind of thing a warranty repair or a recall campaign addresses.
How this mix compares with other model years
| Component group | Here | Typical |
|---|---|---|
| Engine | 35.4% | 16.6% |
| Electrical System | 25.5% | 13.4% |
| Power Train | 20.4% | 10.2% |
| Unknown or Other | 20.4% | 10.2% |
| Service Brakes | 11.9% | 6.4% |
| Steering | 5.0% | 6.2% |
| Air Bags | 2.1% | 5.8% |
| Fuel/Propulsion System | 5.6% | 4.5% |
This compares the subjects of the complaints, not how many there are. A share needs no denominator, so unlike a count it can honestly be held against a norm — but a group sitting above the typical share means people complained about that part more often relative to everything else on this car, not that the car is worse than another.
How serious the complaints were
- 2.5% Crash reported 19 of 773
- 0.3% Fire reported 2 of 773
- 0.8% Injury reported 6 of 773
- 0.0% Death reported 0 of 773
Reported across all complaints on file: 8 injuries and 0 deaths. These shares sit within this model’s own complaints — they say nothing about how it compares to another model.
Recall campaigns
9 campaigns. A recall repair is free at a dealer regardless of how many owners the car has had. Check the car’s own VIN — a campaign listed here may already have been carried out on it.
21V649000 Seat Belts: Critical Fasteners · Seat Belts: Rear/Other: Retractor August 20, 2021
General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.
Consequence: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.
Campaign covered 402 vehicles across model year 2016 — a count for the whole campaign, not for this model year alone.
18V400000 Air Bags: Sensor: Occupant Classification June 14, 2018
General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Malibu vehicles. During servicing, a Passenger Presence System (PPS) may have been installed that was not correctly calibrated to the vehicle's seat type. As a result, the PPS may not properly identify an adult passenger from a child passenger in the front passenger seat, potentially causing the air bag to not deploy when it should, or causing the air bag to deploy when it shouldn't.
Consequence: In the event of a crash, improper air bag deployment can increase the risk of injury.
Remedy: GM will notify owners, and dealers will replace the front passenger PPS seat service kit, free of charge. The recall began August 7, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18208.
Campaign covered 66 vehicles across model year 2016 — a count for the whole campaign, not for this model year alone.
18V358000 Fuel System, Gasoline: Delivery: Fuel Pump May 31, 2018
General Motors LLC (GM) is recalling certain 2015-2018 GMC Canyon, 2016-2017 Buick Envision, 2016-2018 Chevrolet Colorado and Malibu, 2017-2018 GMC Acadia, 2018 Buick LaCrosse, Cadillac ATS, Chevrolet Equinox, and GMC Terrain vehicles. The high pressure fuel pump may detach from its mounting flange, possibly resulting in the pump damaging the high pressure fuel line.
Consequence: A damaged fuel line can create a fuel leak, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will replace the high pressure fuel pump, and high pressure fuel pipe, free of charge. The recall began July 2, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18188.
Campaign covered 895 vehicles across model years 2015, 2016 — a count for the whole campaign, not for this model year alone.
16V781000 Air Bags: Side/Window October 26, 2016
General Motors LLC (GM) is recalling certain model year 2016 Chevrolet Malibu vehicles manufactured November 18, 2015, to June 7, 2016. The fabric of the side-impact air bag cushion may tear during deployment.
Consequence: If the air bag tears during deployment, the air bag may not perform as designed, increasing the risk of injury in the event of a crash.
Remedy: GM will notify owners, and dealers will inspect and, as necessary, replace the air bag module, free of charge. The recall began October 27, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 16079.
Campaign covered 18 vehicles across model year 2016 — a count for the whole campaign, not for this model year alone.
16V502000 Electrical System: Ignition · Power Train: Automatic Transmission: Control Module (TCM/PCM/TECM) July 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Campaign covered 8,367 vehicles across model years 2010, 2011, 2012, 2013, 2014, 2015, 2016 — a count for the whole campaign, not for this model year alone.
16V272000 Electronic Stability Control (ESC) May 5, 2016
General Motors LLC (GM) is recalling certain model year 2016 Chevrolet Malibu vehicles manufactured March 7, 2016, through March 12, 2016. The memory chip in the electronic brake control module (EBCM) may fail and cause the loss of electronically controlled brake systems including anti-lock brakes (ABS) and electronic stability control (ESC). As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence: If the EBCM fails the primary braking system will still function, however, the loss of ABS and ESC increase the risk of a crash.
Remedy: GM will notify owners, and dealers will install a replacement EBCM, free of charge. The recall began on June 17, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020). GM's number for this recall is 39440.
Campaign covered 66 vehicles across model year 2016 — a count for the whole campaign, not for this model year alone.
16V151000 Air Bags: Side/Window March 11, 2016
General Motors LLC (GM) is recalling certain 2016 Malibu vehicles manufactured February 16, 2016, to March 5, 2016. The two weld studs that mount the front and rear side impact air bags may fracture and separate from the air bag during deployment. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) No. 214, "Side Impact Protection."
Consequence: Fractured weld studs may allow the side air bag to move out of position during deployment, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the side air bag modules, free of charge. The recall began on April 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 31820.
Campaign covered 3,137 vehicles across model year 2016 — a count for the whole campaign, not for this model year alone.
16V125000 Air Bags: Frontal March 2, 2016
General Motors LLC (GM) is recalling certain model year 2016 Chevrolet Colorado vehicles manufactured January 19, 2016, to February 2, 2016, Chevrolet Malibu vehicles manufactured January 9, 2016, to January 26, 2016, and 2016 GMC Canyon vehicles manufactured January 21, 2016, to February 4, 2016. The driver frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash.
Consequence: An improperly inflated air bag increases the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver side frontal air bag module, free of charge. The recall began on April 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 28030.
Campaign covered 1,579 vehicles across model year 2016 — a count for the whole campaign, not for this model year alone.
16V084000 Electrical System: Software February 11, 2016
Genera Motors LLC (GM) is recalling certain model year 2016 Chevrolet Camaro, Malibu, Silverado and GMC Sierra vehicles. The radio may intermittently fail to provide an audio warning when the key has been left in the ignition and the door is opened or when the driver does not fasten their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standards (FMVSS) number 114, "Theft Protection", and/or 208, "Occupant Crash Protection."
Consequence: An unbelted driver is at a greater risk of injury in a crash.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 15808.
Campaign covered 139 vehicles across model year 2016 — a count for the whole campaign, not for this model year alone.
NCAP crash-test ratings
| Variant | Overall | Frontal | Side | Rollover |
|---|---|---|---|---|
| 2016 Chevrolet Malibu 4 DR FWD | 5 | 5 | 5 | 4 |
Ratings are out of 5 stars.
Pre-purchase inspection checklist
Written and checked by someone who does this work; it is not derived from the data. The complaint counts decide only the order: the assemblies this model’s owners complain about most come first.
Engine and cooling system
Related complaint groups: Engine (274), Engine and Engine Cooling (2)
Come to a cold car. A warmed-up engine hides a hard start, smoke and knocking. If the car is already warm, that is a yellow flag: ask for 30–40 minutes to let it cool. A refusal to let it cool is a red flag.
With the car parked
- Oil: level, color, consistency. Level above maximum plus a smell of fuel on the dipstick means the oil is being diluted with fuel.
- A whitish film on the oil filler cap alone is usually condensation from short trips in cold weather, not cause for alarm. What matters is the dipstick: a coffee-with-milk emulsion on the dipstick requires serious further inspection. A further indication is coolant hoses that are hard and under excess pressure.
- Coolant: level, color, no oil film. Open the reservoir only on a fully cooled engine.
- Leaks: under the engine, along the sump seam, around the valve cover, along the hoses and the radiator.
On the road and after
- Cold start: how long the starter cranks, smoke in the first seconds, knocking that goes away as it warms up.
- Temperature over the whole drive. Idle with the air conditioning on: the fan should cut in and the needle should not climb.
- After the drive, switch off, wait a couple of minutes and look for fresh drips under the car.
Red flags
- A freshly washed engine bay on a high-mileage car
- Thick white smoke after warm-up
- Temperature climbing in traffic
Electrical system
Related complaint groups: Electrical System (197), Exterior Lighting (18)
With the car parked
- With the ignition on, before starting, every warning light should come on and then go out once the engine runs. None coming on at all is worse than one staying lit: the bulb may have been removed or disabled in software.
- Click through everything: windows from every switch, mirrors, heated elements, climate control on all settings, the radio, the camera, the parking sensors, cruise control.
- Every exterior light, including running lights, brake lights, side repeaters and the license plate lamp.
- Battery terminals for corrosion, and the date on the battery.
- Cabin and trunk for signs of water: damp carpet under the mats, condensation in the headlights, rust on the seat mounts. Water in the electrics causes faults that are extremely hard to trace.
On the road
- Whether anything dims when several high-draw consumers are switched on at once.
- A second hot start after the drive.
Red flags
- A dashboard with no warning lights at all when the ignition is on
- Signs of water ingress
- Homemade wiring, twisted joints, tape under the dash
- Several small non-working functions at once — usually one common root cause
Automatic transmission
Related complaint groups: Power Train (158)
Checking the fluid level during an inspection is usually not possible — many cars need a lift, some have no dipstick at all, and Honda’s procedure differs from the rest. So this assessment is built on behavior, not on fluid.
With the car parked
- Move the selector P → R → D and back with the brake held. Each engagement should be a soft nudge, without a thump and without delay. Repeat two or three times in each direction.
On the road
- Shifts without noticeable delay or thump, both under acceleration and when slowing down.
- Pay particular attention to the 1-2-3 and 3-2-1 transitions — they carry the most load.
- Hard acceleration at full throttle: the revs should not flare without the car gaining speed.
- On a CVT the revs should rise smoothly, without steps, droning or jerking.
Questions for the seller
- Has the fluid been changed, and is there proof. Regular changes are a substantial plus for the car; their absence at high mileage is reason for caution.
Red flags
- A stored transmission fault code (a scan tool is worth having)
- Slipping under load in any form
- Recently cleared codes with no explanation
- The seller offering to "just change the fluid" when it is black and burnt — that is cosmetic cover over wear that has already happened
Cost if it needs work: Expensive. The most expensive of the likely assemblies; a repair is often comparable to the value of the car.
Axles and CV joints
Related complaint groups: Power Train (158)
With the car parked
- Turn the steering to full lock and inspect the outer CV boots on both sides for cracks, splits and thrown grease on the inner face of the wheel and in the wheel arch. A split boot on a joint that is still sound is a cheap repair today and an expensive one in six months.
On the road
- Empty parking lot, steering at full lock, slow circles in both directions. A rhythmic clicking points to an outer CV joint; the side is identified by the direction of the turn.
- Vibration under acceleration in a straight line that disappears when you lift off may indicate an inner CV joint.
Cost if it needs work: Relatively low. A good indicator of how the car has been treated overall.
Brakes
Related complaint groups: Service Brakes (92)
With the car parked
- Brake fluid level and color. Clear yellow is fresh; dark brown has not been changed in a long time.
- Fluid at the lower mark with no leaks usually means worn pads: the pistons have extended and the fluid has moved into the calipers.
- Pad thickness through the spokes of the wheel. Check the disc for a lip at the outer edge and for deep scoring.
- Inside face of the wheels: an even dark dust film is normal; one wheel noticeably dirtier than the others may indicate a sticking caliper.
- Hoses for cracks and bulges, lines for corrosion.
On the road
- First stop at low speed: the pedal should be firm, with no sinking.
- Accelerate to 40–45 mph and brake moderately. Pulsing through the pedal or the steering wheel usually means warped discs.
- Braking on flat dry pavement: pulling to one side requires further inspection.
- The ABS light should come on with the ignition and go out after the engine starts.
- A feeling that the car is driving "as if towing a trailer" may indicate binding brakes.
- The car squatting at the rear when pulling away may indicate parking-brake cables or stuck rear shoes.
After the drive
- Hold your palm near each wheel without touching the disc or the caliper — after braking they will burn you. Compare only left against right on the same axle: the front is always hotter than the rear, and that is normal. A noticeable difference between the two wheels of one axle requires further inspection.
Red flags
- The pedal slowly sinks to the floor when held down
- An illuminated ABS or brake system warning light
- Fresh fluid together with completely worn pads
Cost if it needs work: Moderate. Confirm actual cost against local prices at the time of purchase.
Suspension, control arms, steering
Related complaint groups: Steering (39), Suspension (18)
With the car parked
- Rock the steering wheel briskly left and right. Knocking and free play point to ball joints, tie rod ends or the rack. This is the most productive check of this assembly without a lift.
- Rock each wheel at 12 and 6 o’clock (ball joint, wheel bearing) and at 3 and 9 o’clock (steering linkage).
- Inspect the bushings for cracks and separation, and the ball joint boots for damage.
On the road
- Dull knocking from the front over small bumps. The cause cannot be determined without a lift: sway bar links are inexpensive, control arms cost several times more, and by ear the two are indistinguishable. A knock is grounds to require an inspection on a lift before purchase — not grounds to walk away from the car.
- Whether it pulls to one side on a level road, and whether the wheel returns to center after a turn.
Red flags
- Uneven tread wear — almost always alignment
- A recent alignment in the paperwork with no explanation of why
- One control arm noticeably newer than the rest
Cost if it needs work: Low to moderate. Depends on what turns out to be the source. Plus an alignment after the replacement.
Airbags and the VIN recall check
Related complaint groups: Air Bags (16), Seat Belts (9)
The most reliable procedure in this library — it does not depend on hearing, experience or inspection conditions.
Required procedure
- Take the VIN from the car itself — the windshield on the driver’s side, the door pillar, the paperwork — not from the listing.
- Check that VIN in NHTSA’s official recall lookup.
- A recall repair at a dealer is free regardless of how many owners the car has had. An open recall is a reason to visit a dealer, not a reason to haggle.
- An open airbag recall is grounds not to buy the car until it has been fixed.
Inspection
- The SRS light should come on with the ignition and then go out. Not coming on at all probably means it has been disabled deliberately.
- Airbag covers on the wheel and dash: uneven gaps, mismatched texture, marks from removal.
- Seat belts: pull each one out to full length and check for chafing, tears and water marks. The inertia reel should lock when pulled sharply.
The Chevrolet Malibu year by year
| Model year | Complaints | Median mileage | Recalls |
|---|---|---|---|
| 2010 | 1,337 | 82,000 | 3 |
| 2011 | 951 | 80,000 | 3 |
| 2012 | 882 | 85,600 | 2 |
| 2013 | 794 | 69,000 | 10 |
| 2014 | 324 | 58,000 | 6 |
| 2016 (this page) | 773 | 50,000 | 9 |
Read the mileage column down this table with care. A newer year has simply been driven less, so its median sits lower for that reason alone — the figure is censored from above by how long the cars have been on the road, not only by how they were built. The same applies to the complaint counts: an older year has had more years in which to collect them.
Where the mileage figure does compare cleanly is between different models of the same year, which have had the same time to accumulate miles.